I took a chance on this machine a few weeks ago for £4, poor little thing


Was advertised as being dead. I took a chance on it being the cable and not the motor...

It had blown itself apart by the plug (common issue)
The rest of the cable wasnt up to much either

But, I re-stripped the end of the cable, fitted a new plug as the white one was cracked and voila, she fired up beautifully
Seems to have gained a different coloured upholstry tool at some point


The floor tool has a metal soleplate too, I thought they were only on DC02's? All DC05's I've seen have had plastic sole plates.
One problem that wasnt mentioned on the ad is the broken extension pole


I did try to fix it, but it held for about 2 minutes before breaking again... luckily I have a spare DC05 Extension wand in the loft (handily) so swapped them around.
I moved onto the stripdown now.
Floortool first

Soleplate off

Pushed out the litter pickers from the back


The wheels removed easily thankfully

as did the attachment bit

I cant take these apart anymore without damaging them so left it as that and washed it whole..
Removed the banana end from the hose and got the tools ready for washing

Finally on to the machine

Cyclone off

Post motor filter seems ok

Oh

The pre filter looks ok though

popped the top handle/filter housing lid off

Removed the seal

removed the mini cyclone thing

and removed this hair from it

I looked at the wheels next

but wasnt able to get the centre bit out without potentially damaging it, so left it for now
Instead, I managed to get at all the screws with the wheels still on to get the case open


Removed the cable guide


Can see the back of the wheels now, and the back of the plastic pegs

You can see where I tried to lever the left one out from the front... they smack out easier from behind!


motor to cord rewind wiring

Looking at the cord rewind, it seems different to madrats guide


The cable unplugs from the reel and simply pops out of the locating tabs

Without the weight of the cable on it though, the reel started to veeerrryyy slloowwllyyyy unwind so I grabbed a cable tie to stop it loosing tension


Onto the motor now. The front bumper is removed


The motor housing slides out of the chassis now

The front hose holder and cord rewind and power buttons pop off the chassis

Quick wiring reference shot

Wiring released, the motor can be removed


Removed the front wheel

Onto the cyclone next

Cyclone bin emptied

Onto the cyclone unit, 2 screws off

ans the release valve comes off

and then apart



Rest of the cylone comes apart by pulling

All done! Hardly any screws at all on a DC05!

Everything was washed and dried. I put a new cable onto the cord rewind

Lovely

Played around with the tension a bit and now the plug nearly smashed through the casing if you leave the reel to do its job...
General re-assembly now
Cyclone

Shroud back in

top cone fitted

Release valve re-assembled



lower cone back together

To the chassis now. front wheel back in

Motor went back in the motor housing


and the motor housing was done

fitted the hose holder

Then, I refitted the switch, and lowered the top chassis housing and bumper back on

Cord rewind next

Lower chassis housing fitted

Hose port snapped on next

followed by the pedals (had to remove the hose port to fit the cord rewind pedal...)

Back on with the wheels

and in with the pegs

New post filter in



Washed pre filter back in



floor tool back together


And done!


